LIGNIN AS A DUST RETARDANTQuestions & Answers
(Answer)Estimates of the effectiveness of Lignin in controlling dust range from 80% to 100%. In general, the product is 100% effective when first applied and gradually loses some effectiveness with the passage of time, depending on the amount and type of traffic using the road and the amount of summer rainfall that occurs.
Q. How long does it last?
(Answer)Usually, one application of the product will be effective for the entire summer season. At the end of the season, Marion County will be grading all gravel roads, at which time most of the benefits of the product are terminated. Should a heavy rain occur after the product is applied, the effectiveness may be significantly reduced for the remainder of the summer.
Q. How much does it cost?
(Answer)For information on current costs; please click on the below link where you will find contact information for the approved contractors.2011 Lignin Permit
Q. What is the minimum width of road The approved contractors will apply the Lignin on?
(Answer)Application shall be centered on the gravel road. If the road is less than 16' in width, the entire road shall be shot (burm to burm). If the road is over 16' in width, the minimum width of application is 16'.
Q. Are there any bad effects from the use of Lignin as a dust retardant?
(Answer)As mentioned, the product may lose effectiveness as a result of heavy rainfall. Other undesirable characteristics are:
1. Traffic delays may be necessary following application of the Lignin. This is to allow the product to be absorbed into the road surface.
2. After application, there may be puddles of Lignin still in evidence for up to 12 hours. Later, rainfall may also cause the product to splash. If splashing occurs, the product can be washed off with soap and water. Lignin DOES NOT CAUSE RUSTING.3. Under heavy traffic the road surface may begin to develop ravel and/or potholes. There is no way to repair this damage. Should the road surface become excessively rough, Marion County will have little choice but to return the rough section of road to its original condition by performing grading work.
Q. How about environmental effects?
(Answer)According to the manufacturer, the composition of Lignin is:
Tree pulp and liquids..........27%Sugar..................................12%Ash.......................................8%Water..................................53%
Q. When can Marion County roads be treated for dust abatement?
(Answer)Application of lignin product will be permitted between May 15th and June 30th, 2011. After June 30th, 2011 applicant will be charged $130.00 per hour for grading (2-hr minimum).
Q. Where can I find more information concerning the use of Lignin as a dust retardant?
(Answer)Both the Bureau of Land Management and the U.S. Forest Service have experience with the use of this product at the national level, as well as Jackson County, at the state level. Environmental concerns may be addressed to the Department of Environmental Quality.